Lb-white Guardian with Smart Sense - Spark Ignition (60K / Manual de usuario

Propane-VaporWithdrawaland Natural GasOwner's Manual and InstructionsGUARDIAN ®Agricultural Animal Confinement Building Heaters with Smart Sense™

12. A qualified service agency must check for properoperating gas pressure upon installation of theheater.13. Light according to instructions on heate

1. Assemble according to the illustration and tighten alleyebolts securely. See Fig. 3.FIG. 32. Be sure heater is securely fastened and is hangingleve

REGULATORNIPPLEREGULATOR VENTGAS HOSEADAPTERSEDIMENT TRAPTO CONTROLVALVE INLETGANIPPLEVALVE, MANUALSHUT-OFF11MANUAL SHUT-OFF VALVE, HOSEAND REGULATOR

12 The Smart Sense™variable rate heater incorporates asignal conditioner board in the control box. This signalconditioner takes the control signal s

If the heater is to be shut down for cleaning, maintenance orrepair, follow steps 1 - 4. Otherwise, set the buildingcontroller to off.1. Close all ma

WARNINGThis heater may be washed only on the external caseassembly provided:A. The heater is disconnected from the electricalsupply.B. All access pane

151. Remove the screws securing the motor mounting plateto the fan housing. See Fig. 11. (AD100 shown)2. Pull the fan and motor assembly from the hous

16AIR PROVING SWITCH WITH PADDLEThe air proving switch must work properly to allow anignition cycle. If the air proving switch contacts donot close o

The following describes the function of the transformerslocated in the control box during a call for heat. The larger 40 VA transformer supplies 24 v

The following explains a typical procedure to be followedin checking gas pressures. Consult the dataplate on the heater or page 4 in thismanual for

19READ THIS ENTIRE SECTION BEFOREBEGINNING TO TROUBLESHOOT PROBLEMS.The troubleshooting flow charts on the following pagesprovide systematic procedure

20OPERATION SEQUENCE:— A call for heat occurs from the building controller.— 115 VAC is sent to:-- 40 VA transformer and to ignition control-- 20 VA

21ProblemLED constant onRed LED noton during a call forheat. Heaterdoes notoperate.Normal OperationIs heaterconnected to itspower supply?Connect it t

22Two TimesAir provingswitch doesnot closeduring a callfor heat. Are air provingswitch contactsstuck open?(Perform continuitycheck.)Does fan motor sta

23Three TimesIgnition failure. The module hasgone into safetylockout.Is LP tankfull and properly sized and are all gas supply valves to heater open?F

24If ignition control module does not reset, then replace the control. (Internal fault.)If ignition control module resets, then have qualified elect

25Electrical Connection and Ladder Diagram++1 2 6 7 5 3

26Heater Component FunctionAir Proving Switch Safety device used to insure that the proper air flow is beingachieved before the gas valve is opened.

27Parts IdentificationPARTS SCHEMATIC

28Parts IdentificationPARTS LISTItem Description Part Number1 Regulator, 2nd stage, vent over outlet Propane Gas 06553*Regulator, 2nd stage, vent over

WARNINGFire and Explosion Hazard Not for home or recreational vehicle use. Installation of this heater in a home orrecreational vehicle may result i

Contact your local L.B. White dealer for replacement partsand service or call the L.B. White Co., Inc. at 1-800-345-7200for assistance. Be sure that

This Owner's Manual includes all options and accessoriescommonly used on this heater. However, depending on theconfiguration purchased, some opt

Maximum Input (BTUH) 60,000 100,000Minimum Input (BTUH) 15,000 25,000240 400 11.0 10.0 11.0 10.010.0 9.0 10.0 9.0 0.8

5This heater uses Smart Sense™ technology for variablerate heat control. L.B.White has worked with agriculturalbuilding control manufacturers for the

6Propane gas and natural gas have man-made odorants added specifically for detection of fuel gas leaks.If a gas leak occurs, you should be able to sme

1. Do not attempt to install, repair, or service this heateror the gas supply line unless you have continuingexpert training and knowledge of gas heat

1. Read all safety precautions and follow L. B. Whiterecommendations when installing this heater. Ifduring the installation or relocating of heater,